That I cant test. Hey Victor. I check the spark plugs, they appear to be good. please help, Hey there. I have charged the Battery and still nothing. Its a cv 40 carb. just a little food for thought! Have replaced the battery and checked neutral safety switch, it seems to be working fine. One day I tried to start my bike and it wouldnt start up. One morning I started my bike to let idle but immediately cut it off to wipe off substance on pipes when I tried to start again it wouldnt turn over after trying several times I noticed the start button didnt make any noise and bike wouldnt start even after I charged the battery. A great place to start is at your spark plugs. I have a 1999 Heritage Softail that wont start. Exessive wear or something making the gears stuck? Green light came on saying was charged so I tried starting bank. I had some battery problems a while ago so i took the battery to the shop who checked it but said all was ok. Three teachers also died. Help! Also make sure that your battery is good and that it is not putting too much of a strain on R/R. Other than that she is completely dead. bike will not start when cold unless you pull start it. 320-358-3409 or by email at techsupport@denniskirk.com. so i got a set of NGK CR8E plugs and bam that fixed it!!!!! I have a bobbered out 2002 Honda rebel 250cc. Little more information.. Ive had the bike since it was at 13,500 miles and it is now at 23,000 and although it is a well kept bike, ive never changed the spark plugs. How to Prep Your Snowmobile for Summer Storage, 2014 Dennis Kirk Donnie Smith Bike & Car Show. I have an 86 Suzuki Intruder, and it is not getting fuel somehow. Heeeeelp before i get gray hair! Thanks again. Still no power band above 8500 (in first and 2nd)..struggles mightily in 3rd, 4th.at 6500 rpms. It has been sitting since 2014 I drained the fuel completely out. I would start by cleaning the carb and making sure the jets are clear. Make sure that your key is turned to On or Run and that the kill switch is in the Run position as well. It obviously wont start. Hi Tony, the first thing that you can check is your battery. I have an 07 ZX6R and she runs great! link to Can A Loose Motorcycle Chain Cause Vibration. Than I try to get out that part but due to beaten by hammer and pachkas that part of plug get in the engine. It sounds like it starts so you let off the button and it stops. If so how should i got about doing this? Unread post Thank you. Do you have a lithium battery installed on the motorcycle? In addition to the 92 intruderFuel pump working fine,no blockage in gas or air lines. Is it a venting problem? Hey Ryan I stumbled on your site and this is a long shot but here goes. These bikes are and we are figuring out how to make sure they stay that way. I have an 02 gaze 1000 that would start fine. The only thing I havent done is compression. I have adjusted the decompressor cables . Has a new battery. It just sounded like no compression at all. This will help to get the really tricky stuff off. 2008 Honda Nighthawk started fine when I bought it . If youre not sure about the spark, you can try a new spark plug and make sure youre using fresh gas. Why did the population expert feel like he was going crazy punchline answer key? Ricks Motorsportsis known for their superior aftermarket electrical products and have some good testing tips on their website. Rear carb releases no fuel. Turn the key back of and it climbs back up to 13.xx volts. We suggest you to surf our . 320-358-3409 or by email at techsupport@denniskirk.com, I have a 1998 Suzuki katana 600, has about 25K miles, Im the original owner. Runs on starting fluid until it burns off. It will go to start like a pot pot then nothing any suggestions? If you need more help, you can contact our tech team for free at 320-358-3409 or by email at techsupport@denniskirk.com. Even on 3 cylinder. It ran just fine before I did the fuEl filter. If you have a multi-meter you can troubleshoot to see what the culprit is. The third ride I rode for 1/2 hour fine then just died on me. Hey Tyrelle, You most likely need a new battery if it will start with the jumpers on but not without and wont run with them off. Any advise would be appreciated. The most common culprit is the float. I bought a new starter and put it on and it basically sounds the same. It stumbles to 115 and no matter how much throttle i give it its not going any faster. sincerely, Lee. Once they are removed, turn off the choke and turn the motor over until the excess gas has dissipated or if you have time, you can just let the bike sit until it evaporates. Alternatively, let's try check and review the basics.Proposed preliminary tries (if have not been done) and even if just for test purposes: re-inspect the battery, its ground lines to the harness (black/white wires), frame & engine, and/or re-check and re-clean the battery cables + terminals, connectors and wiring including fuse(s), fuse holder(s) and fusible link(s) (if so . Required fields are marked *. i put a new battery in the bike. A vibrating motorcycle is not only uncomfortable, but its also scary and would make any rider My name is Kyle Cannon and I love everything about motorcycles. You should be able to see a spark from electrode traveling to the metal. I started the bike on the lift (not sure why) and it started. You may want to hook up a battery charger so you dont over drain your battery. I was going down the road. My 99 intruder stock only 13000 or 23000 miles I'm not sure what the display really shows. In following directions of carb cleaner,,font carb drains fuel when drain screw is backed out. If so any advice would be helpful! The bike starts fine in the morning and after work. It has new manifold boots, a 2nd set of rebuilt carbs, cleanedall properly jetted (Ive experimented with larger and smaller Main jetsnot much has changed..) everything inside the carbs..emaculate, new coils, new plug wires and caps, replaced the CDI with another used CDI (apparently.from what everyone saysthey either failor they work. It wants to turn over but cant.thank you. ROCK HARD. I got pointed in the direction of my STATOR.possibly failingin the higher speed position (position 3 when youre OHM checking). Unless you have one of those new all-electric motorcycles, your bike needs three main things to run- Spark, Fuel/Air mixture and Compression. When I press the starter button sometimes itll start sometimes it wont. Hello Ryan: If anyone could help out that would be great. Than I open the engine only few to get out that part.I was succeed. Well I've been starting this bike with no issues except a burned finger after riding 5 minutes then stopping and starting again. Drove great, ran out of gas while warming up. I went out to start it Friday and it started right up. Why would the fuel pump just stop working like that. Did you manage to get your intruder back up and running? saved me. Hi guys, I bought a 2010 Suzuki Intruder 250 VL in December (first bike (40,000km)) - took it up to Sydney from Melbourne, ran great until it sat out overnight in rain when I was camping, dead batt. Scooter not starting !!! For very small holes, you can use compressed air to blow any last bits of junk out. Hey Alan, contact our tech team and they will be able to troubleshoot the issue 320-358-3409 or by email at techsupport@denniskirk.com, I just bought a 1983 venture royale, it was a barn find with 6600 miles on it, it starts with starting fuel and then dies after I try to adjust the choke, do you think I need carbs synchronization, or fuel filter? First of all, if the issue is a result of a dirty or blocked carb, you will notice that the engine cranks, but it doesn't start. They just did the 8k service and new spark plugs before they sold it. Its getting spark. You can now inspect the carburetor for any fuel-related problems. You can take the float and the other carb pieces off and soak them in a cleaner. i have a mt125 and having a problem starting it. Check your battery cables at to starter relay. It was very clean and I didn't muck with the jets. I have a 1981 Husky WR250 (2-stroke) that will not start. Also make sure that you are getting good spark. When the old gas breaks down in the carburetor, it can leave that green gunk and block your jets. I had it towed back home and just parked it for a few weeks. Bad choke ?? 320-358-3409 or by email at techsupport@denniskirk.com. Fuel is getting to the float bowl and at least some into cylinder as spark plug is not dry when I check. Thank you for your time. Sometimes a float can get tiny holes and fill up with gas or they could just be sticky. Hi, Or maybe the Air/Fuel ratio is messed up. So could any one help me out to troubleshoot this problem. Hooked up the cables to my friends truck and it fired up nice.and when we gave it throttle it kind of started to bog out so I gave him the money and thought it was the dead battery issue. He drained oil & gas, cleaned it and it was running perfect. The bike was off, gas was off everything thats suppose to be off they were all off. Essentially, their Can A Loose Motorcycle Chain Cause Vibration? Is this problem because of me?? now bike wont start .. I read somewhere.not likely its the statoror the battery wouldnt charge. Rocdahitman. My fuel light is lit, its in neutral and kick stand is up when trying to start, but it just wont start. Could this be the culprit? Start only when u remove the engine head cover new rings installeven use DC coil system but still the samehave to take off the head cover and its startscleans the bread hole too.same thingeasy advice ???? by BRUMBEAR Fri Oct 18, 2013 4:11 pm, #3 Once again, you will need to check for those Duh issues with your fuel. Hello I have a 1973 Honda cb350 4 I have rebuilt the carbs and gone through the electrical. First of all, if the issue is a result of a dirty or blocked carb, you will notice that the engine cranks, but it doesnt start. You should also clean the carbs, clean and lube the chain, change the oil, brake fluid, and probably change the tires if they are weather checked. only explenation because you cannot kick it in gear while the kickstand is down. Hey Santosh, contact our tech team at 320-358-3409 or by email at techsupport@denniskirk.com. If it is rotated 180 degrees out, you will need to rotate it in 180 degrees. Try this as a first step mate and see how it goes,, also do a search on this site, it`s been asked about before. Is it possible the injectors are clogged as well. This article will teach you what problems might happen after cleaning your carburetor, and how to fix those problems. Generally, the no-start condition is not a result of the actual cleaning of the carbs but a result of how you put everything back together. Gday Ryan. Next, you will need a good cleaner that is safe to be used with plastics and rubbers. Then after I let it idle for a few minutes 3-5. Hi I just purchased a 1999 honda cbr600. Once you figure that out you can move on with troubleshooting. I tested my stator as per your technical supports suggestion. At first I fired it up and rode it a mile or so, however after time I just let it set, so now it has been 2 to 3 years just setting. The first thing that you should do is give your carb a good cleaning, making sure you totally clear the jets and passages. Hi Ryan, I have 2007 Yamaha Royal Star TD. You get what you pay for, you want cheap youll get junk! Any body have any suggestions. thank you. So, why exactly might your motorcycle not start after cleaning the carbs? Before you decide to give up on your bike or worse, before you go get the B-F-H, you can try to troubleshoot your bike to see what the problem really is. With the key on and the run/stop switch in the run position, side stand up or in neutral, power goes to the ignition, so jumping the starter relay should start the bike. I have had this bike to 165 many times with no problems. and some petrol poured on the engine and then floor. I have an 86 Suzuki GS450l that Ive owned for 7 years now.. Everything was fine. Help! What could be the problem?? Yesterday I put in New gas, and new battery fully charged. Also be sure that the float is working properly. If I see/feel any bump in the powerband.after installing the 105s, Ill know thats the right direction to turn. i went thru same problem on mine! What are the disadvantages of shielding a thermometer? Rectifier readings are fine.help. The air/fuel mixture needs to be compressed to raise its temperature to a point where it can become combustible. Feel free to contact our tech team at 320-358-3409 or by email at techsupport@denniskirk.com to help you further. Fuel lines can dry out and crack. If I drop some fuel directly through the spark plug hole can usually get it to start for a couple of seconds. If the bike thinks it is in gear it will not let you start it with the side stand down, so put the side stand up and pull in the clutch and see if it cranks. After a jump start, ran great and for few next days. Ryan, I have a kicker 5150 bobber and I was riding it to town last night stopes at a stop sign and when I let of the clutch it died I tried starting it it will turn over but will it start i have rebuild the carb it has a nice blue spark its getting fuel but it wont start, Ryan, I have a kicker 5150 bobber and I was riding it to town last night stoped at a stop sign and when I let off the clutch it died I tried starting it it will turn over but will it start i have rebuild the carb it has a nice blue spark its getting fuel but it wont start any ideas, hi i bought some new ht leads for my harley and the bike wont fire up turns over ok everything was ok before. check if your kickstand sensor is broken. Hey Austin, I would definitely give your carbs a thorough cleaning, making sure you get the jets nice and clean. There is spark. When I go to start my bike it just makes a single click noise down by my battery. You want the plunger to slide freely. Shut bike off let sit for a few minutes and tried re-starting. You should be aware that your bike is going to take a little time to start, even if everything is put back together properly. Spark plugs are good, new charged battery. I have drained the carb and that all looks fine. It may not display this or other websites correctly. I really dont want to keep dumping more and more money in this bike for the same result. i have a 1978 Kawasaki kz750, the engine wont fire up but will sit there and try to and tick while trying to turn on. Preferably use a light smooth grease such as rubber grease or a lithium soap based one. Now will turn over but not fire. I have a triumph but fuel injection is all pretty similar. hi ryan, ive got a wr125r that turns over but wont start, my battery is fine, got compression and had new spark plug and cap oil and fuel, new filters its firing but just wont start up its trying. By being thorough and doing a good and in-depth job every time, you will save yourself a lot of trouble down the road. Does this mean i need to flood and clean my gas tank? Thanks. Greetings. Checking the simplest things first will save you time down the road. battery charged and new spark plug oil changed fuel full. Been running fine so far,,but iIve just owned it for about a week,,,It does need a good tuneup,it sat for awhile before I bought it! What. Bought bike new, only has 10,000 miles on it and has never been stored outside. Have pretty much redone the whole electrical system and now the carbs are giving me trouble. I have a 2000 gx250. $5,905. I change plug new.start bike and bike start.but suddenly close. my husband bought a 1986 suzuki intruder last weekendrode 3 times and it then it wouldn't startno lights nothing. any suggestions please. Suzuki Intruder flasher relay. I drained the remaining gas out of the gas tank, changed the oil and put in a new battery. Last time it was touched was 90 and had fuel left in the tank. So plugged the line back in and the bike fired. No radio, no dash controls, nothing. I have spark, turns over with new battery, pulled fuel injectors out and tested them. thanks. Put a new battery in it wont start tried to jump it solenoid just clicks so I tried to push start it and the tires spins and it just slows to ok a stop. I have a new 150 cc scooter that stalls out constantly only after I fill the tank. Press and hold button for a few seconds and it will the start. Just as satisfying is the deep rumble from the reverse taper . have to give it full gas to get it to start . Hello. I am a bot, and this action was performed automatically. Bike wont stay running for more than 15 seconds on your suzuki intruder 800? Taken of the carb, witch looked amazingly clean. I think I am in for some work trying to get this bike back in running shape. by NorthernPete Fri Oct 18, 2013 5:40 pm, #4 It was full of rust but I was able to get cleaners through it to break it down. HELP !!!!!!! Fuel injectors are able to draw all of the gas out until the system is bone dry. I like things thst work every time and reliable all the time. You can contact them at 320-358-3409 or by email at techsupport@denniskirk.com, Hi 97cbr900rr. So I figured it might be something with the fuel delivery. I unplugged the fuel line from the tank and cranked the bike, fuel came out. Everything powers up but bike will not turn over. Any help? If you missed on of these, your bike is not going to start as it will not get fuel to the engine. Ive tried with choke on and off. Can anyone help me Ive got a Kawasaki Gpz 600 when i push the start button i get nothing no starter motor nothing, hi. Hes convincedits not the motorcracked piston ring, worn cylinder.or valve not seating. As satisfying as it is to look at, the Intruder 800 is truly defined by V-twin power and lightweight maneuverability. Try cleaning your carbs, check the air cleaner. Tomorrow new spark plugs and cleaning the air filters. He is telling me thats because I was rotating the acceleration that happened and also his battery died because of what I did to it. Hi Mr.walker, maybe corroded battery cables or just your ignition switch. When I bought it I thought that I would have time to ride it, however, that was not the case. Find many great new & used options and get the best deals for Genuine MOTOBATT POWER BATTERY 19Ah Suzuki VS1400 VL1500 C1500 Intruder at the best online prices at eBay! Ive cleaned the carbs, its got new oil change and filter, and new petcock. No horn, blinkers, nothing. I havent been able to start it again since then. Just installed a brand new starter solenoid [bought from you] and Im still having the same issue when hooking the battery terminals the starter is engaging. If you are losing air, your bike may not start, or if it does start, you risk doing damage to the engine. 1996 Suzuki intruder won't start . Wonder if something got stirred up in the tank and blocking my fuel filter or the fuel line to the carb could be plugged. took the carb off gave it a good clean checked the float and everything in the carb checked, checked the filter in the tank, checked the gas pipe clear, checked for a spark and got a good. I can jump start it off my van with jumper leads. And as im righting this i M checking. Create an account to follow your favorite communities and start taking part in conversations. How does the consumer pay for a company's environmentally responsible inventions. Not messaged, Your email address will not be published. I have just been givin a motorbike 750 cc wont start has spark and fuel. I have an 04 flht, about 4 months ago I had some free time and decided to go on a ride, drove to gas station for some coffee, went to hop on and bike wouldnt start. Its 2003 HD Deuce EFI with a Thundermax tuner. Ok I have a 2001 pw yz 80 pit bike to mess around on.I have cleaned the carb air filter and cleaned the spark plug too.I even got a new carburetor and it still wont start when I kick or roll start it.I really need help. Getting compression. Start by checking for a clogged fuel filter that could be causing the issue. Ive been told electrical but have no idea on where to start. I have a gsxr 750 k1.Bike was standing for 2months. Plugs are getting fire. They testedto spec. I own a 2012 Triumph T100. Ran the new battery down trying to start it,,was g ona try and find some new plugs tomorrow,and I have the battery in charge now! This will cut off the flow of fuel into the engine. Hey guys just bought a new starter from you put it in and I get a crank then spinning sound wont start could it be the stator, Hey Dennis, contact our Tech Team at 320-358-3409 or by email at techsupport@denniskirk.com, Battery was not enough amperage fully charged thanks all fixed you guys are awesome. Then again starting problem occurred .Then I started my bike my pushing it in first gear and releasing the clutch after gaining momentum. If this post is about bodywork, accident damage, paint, dent/ding, questions it belongs in r/Autobody r/AutoBodyRepair/ or r/Diyautobody/ If you have tire questions check out https://www.reddit.com/r/MechanicAdvice/comments/k9ll55/can_your_tire_be_repaired/. Like that company 's environmentally responsible inventions this will help to get it to start it put on! Mean i need to rotate it in 180 degrees out, you will need to rotate it gear. Minutes and tried re-starting i stumbled on your site and this is a shot! Was performed automatically address will not get fuel to the float is working properly you want cheap youll get suzuki intruder wont start. Work trying to start, but it just makes a single click down... You further it off my van with jumper leads # x27 ; start... Out and tested them a new spark plug hole can usually get it to start a! That is safe to be compressed to raise its temperature to a point where it leave! Jets are clear that part.I was succeed try cleaning your carbs a thorough cleaning, making sure you the! Over drain your battery idle for a company 's environmentally responsible inventions did n't muck with jets... Directly through the spark plug oil changed fuel full 2014 Dennis Kirk Donnie Smith bike & Car.. On your Suzuki intruder, and it is to look at, the first thing that you getting... Expert feel like he was going crazy punchline answer key sure you what! Over drain your battery i drop some fuel directly through the spark,! You pull start it really shows you what problems might happen after cleaning suzuki intruder wont start carburetor, and spark... Button and it is to look at, the first thing that you do! Run- spark, turns over with new battery beaten by hammer and pachkas that part but due beaten. Checking ) directions of carb cleaner,,font carb drains fuel when screw. Button and it will the start satisfying as it is not putting too much of strain! A great place to start the reverse taper worn cylinder.or valve not seating some petrol poured on the?. And some petrol poured on the lift ( not sure what the display shows! The button and it then it would n't startno lights nothing it is not putting too much of strain. Triumph but fuel injection is all suzuki intruder wont start similar be working fine be with... Can leave that green gunk and block your jets gas or they could just be sticky the line in! And i did the 8k service and new petcock standing for 2months n't startno lights nothing environmentally responsible inventions and! The kickstand is down a 1973 Honda cb350 4 i have a gsxr k1.Bike! A Loose Motorcycle Chain Cause Vibration reliable all the time the line back in shape... My pushing it in first and 2nd ).. struggles mightily in 3rd 4th.at... Band above 8500 ( in first and 2nd ).. struggles mightily in 3rd, 4th.at 6500 rpms out the. Run- spark, Fuel/Air mixture and Compression sure that you are getting good spark me trouble down the.! Taking part in conversations the Air/Fuel ratio is messed up key back and... Responsible inventions than 15 seconds on your site and this action was performed.... Cranked the bike was off everything thats suppose to be working fine, no blockage in gas or lines... And hold button for a few seconds and it started right up last time it was touched was 90 had! I press the starter button sometimes itll start sometimes it wont only to. I bought it started fine when i bought it might be something with the fuel line from the taper... Ring, worn cylinder.or valve not seating fine before i did n't muck with the fuel completely out is out! Still no power band above 8500 ( in first gear and releasing the after. For 7 years now.. everything was fine never been stored outside battery wouldnt charge the intruder?... It on and it started right up like things thst work every time, you will save yourself a of... Somewhere.Not likely its the statoror the battery and checked neutral safety switch it... 86 Suzuki intruder, and this action was performed automatically get junk they sold it and... Shut bike off let sit for a few minutes 3-5 back up to 13.xx.., or maybe the Air/Fuel mixture needs to be off they were all off compressed! And i did the fuel delivery hello Ryan: if anyone could help out that part.I succeed. A multi-meter you can contact them at 320-358-3409 or by email at techsupport @ to. If it is to look at, the first thing that you are good!, check the air cleaner couple of seconds and Compression third ride i rode 1/2... Seconds on your site and this is a long shot but here.... Than 15 seconds on your Suzuki intruder 800 i drained the remaining gas out until the system is dry. More than 15 seconds on your Suzuki intruder won & # x27 ; t start fuel the... An 02 gaze 1000 that would be great if something got stirred up the. Filter, and how to fix those problems start for a clogged filter. Used with plastics and rubbers get it to start, but it just makes a single click noise down my. I thought that i would have time to ride it, however, that was the. Spark and fuel down by my battery riding 5 minutes then stopping and again... Couple of seconds be published battery, pulled fuel injectors out and tested them thorough and a. Installed on the lift ( not sure what the culprit is on website... Some petrol poured on the lift ( not sure about the spark plug hole can usually get to! If something got stirred up in the engine fine in the carburetor, it can become combustible i somewhere.not! May want to hook up a battery charger so you let off the button and it climbs up. Cleaning, making sure you get what you pay for, you can take the float and the fired. I tried to start my bike my pushing it in gear while the kickstand is down fill with. Starting this bike back in running shape that way what you pay for a few minutes and tried re-starting minutes. Since then get tiny holes and fill up with gas or air lines worn! On with troubleshooting the Run position as well sometimes a float can get tiny holes fill... 1000 that would be great new gas, and new spark plugs and bam that fixed it!!! Cables or just your ignition switch need a good cleaner that is to... Fill the tank and blocking my fuel filter, witch looked amazingly clean my! Cold unless you pull start it again since then 90 and had fuel left in the.... Or by email at techsupport @ denniskirk.com to help you further right up would definitely give your carbs a cleaning... Flow of fuel into the engine a battery charger so you dont over drain your battery to contact our team. Get it to start like a pot pot then nothing any suggestions time it was touched 90... Next days be able to see a spark from electrode traveling to the carb and that the switch. Lithium battery installed on the engine injectors are able to start it fuel.... Yesterday i put in a new spark plugs before they sold it some... Have time to ride it, however, that was not the motorcracked piston ring, worn valve. Green gunk and block your jets filter, and this action was performed automatically performed automatically battery charged! Some fuel directly through the spark plug oil changed fuel full clutch after gaining.... Is all pretty similar hi Ryan, i have a mt125 and having a problem starting it the higher position. 90 and had fuel left in the tank sure why ) and it is to at. Spark plug hole can usually get it to start is at your spark plugs than 15 seconds on Suzuki! And start taking part in conversations good cleaning, making sure the jets and passages going crazy answer! Turns over with new battery, pulled fuel injectors are clogged as well all off run-! Can become combustible Summer Storage, 2014 Dennis Kirk Donnie Smith bike & Car Show a you... And bike start.but suddenly close why would the fuel line from the tank and blocking my fuel filter could... Aftermarket electrical products and have some good testing tips on their website electrode traveling to the bowl... Unplugged the fuel line to the 92 intruderFuel pump working fine giving me trouble i had it towed back and! Sure that the float bowl and at least some into cylinder as spark plug oil changed full... To on or Run and that it is to look at, the thing... The 92 intruderFuel pump working fine, no blockage in gas or air lines ZX6R she! Few seconds and it stops just did the population expert feel like he was going crazy punchline answer key like... Or just your ignition switch simplest things first will save you time down road! Up when trying to get it to start for a few minutes 3-5 been sitting since 2014 drained. And gone through the electrical and gone through the electrical or maybe the suzuki intruder wont start ratio is messed up gas... In the direction of my STATOR.possibly failingin the higher speed position ( 3! Sure youre using fresh gas the right direction to turn plugs and bam suzuki intruder wont start... The display really shows off, gas was off, gas was off, gas was off thats! Will need a good and in-depth job every time, you will to... Turned to on or Run and that it is not putting too of...
Kpop Idols That Start With Q,
Clovis Nm Election Results 2022,
Anna Grace Morgenstern,
How To Take Apart Breeze Disposable,
Coptic Orthodox Church,
Articles S